電動機的日常維護及保養
時間：2015-7-6 8:37:00 來源：中國工控網 添加人：admin
3HXD1640-150維護及保養若電動機面灰塵過多，會影響其散熱，導致繞組過熱；如果有水油或金屬屑進入電動機內部，會造成短路故障，燒壞電動機。
意電動機的進出風口必須暢通無阻。
3HXD1640-150經常檢查電動機的絕緣電阻。電動機的絕緣電阻般不應低于相380，的電動機的絕緣電阻至少在5以0以上方可使用。所以工作環境較差，如在潮濕多塵及含腐蝕性氣體的場合，更要注意檢查電動機的絕緣電阻。當發現電動機絕緣電阻低于規定標準，應經烘干或浸漆處理，并重新檢查絕緣電阻，達到規定標準燈具安裝注意事項燈具的安裝要考慮到牢固可靠防火防震安全便于檢修及美觀等，具體要求如下件支架除已有鍍鋅或鎮鉻保護層夕，其余的均應涂刷防鐵漆；木臺木底板均應刷調和漆。
時，可用膠質燈座；燈泡功率在100評以上時，應用瓷盾燈座。
不應少于2個。木臺直徑在75，或以下時，可用1個木螺釘或螺栓固定；燈具質量超過38時，應固定在預埋的吊鉤或螺檢上。
4室外燈具的引入線路需做4對照電動機銘牌上的電壓功率電流等，3HXD1640-150經常檢查電動機是否有超負荷的情況。如用電壓相電流是否正常等5檢查電動機的接地裝置是否牢固可靠保持接地地阻在，以下。
上6當電動機在運行中，升較17又找不出明顯，時，可根據其銘牌上的電動機絕緣等級檢測電動機的各部件溫升是否超過標準，如超過標準過高，應停機作進步檢查，排除故障后方可再投入運行7查看電動機軸承是否有發熱漏油現象?？蓪⒙萁z刀放在軸承郅位。用耳朵緊貼浸緣柄聽是否有異常響聲，3HXD1640-150必要時可打開軸承蓋，檢查潤滑油脂是否正常。對變質有問的潤滑油脂應予以更換，更換時應將舊廢油脂清洗干凈。s8隨時注意運行中的電動機是否有摩擦聲尖叫聲或其他雜好防水彎。燈具有可能進水的，應打泄水眼。
----商務熱線---廈門興銳達自動化設備有限公司
聯系人：王文光
++QQ:2851759104
手機：15359273780
電話：0592-5580707 400-855-5103轉001
傳真：0592-5361289
郵箱：2851759103@qq.com
網址：http://www.xmxrdauto.com
3HXD1640-150 RESOLVER EXTENSION CABLE
3HXD1640-170 RESOLVER EXTENSION CABLE
3HXD1640-220 SIGNAL CABLE
3HXD1640-240 Signal cable
3HXD1640-30 RESOLVER EXTENSION CABLE
3HXD1640-40 RESOLVER EXTENSION CABLE
3HXD1640-50 RESOLVER EXTENSION CABLE
3HXD1640-70 SIGNALCABLE
3HXD1666-100 HOSE
3HXD1672-150 CP/CS CABLE PARALLEL
3HXD1672-60 CP/CS CABLE PARALLEL
3HXD1672-70 CP/CS CABLE PARALLEL
3HXD1675-1 CARRIAGE
3HXD1691-110 POSITION SW.CABLE
3HXD1691-130 POSITION SW.CABLE
3HXD1691-150 POSITION SW.CABLE
3HXD1691-170 POSITION SW.CABLE
3HXD7109-1 PRODUCT MANUAL ENGLISH
3HXG1000-10 CABLE
3HXG1000-101 WELD PLATE
3HXG1000-11 CABLE
3HXG1000-12 CABLE
3HXG1000-138 Ball bearing
3HXG1000-151 CONNECTION FEMALE 8P
3HXG1000-152 Pin device
3HXG1000-153 Housing device
3HXG1000-156 Pin device
3HXG1000-157 Housing device
3HXG1000-162 Rubber element
3HXG1000-165 Coupling
3HXG1000-170 Coupler
3HXG1000-176 Bracket for cable chain
3HXG1000-178 Cable bracket
3HXG1000-198 Coupling
3HXG1000-199 Gear box
3HXG1000-20 Coupling
3HXG1000-201 Gear box
3HXG1000-203 AIR CONNECTOR
3HXG1000-209 BALL SCREW + NUT
3HXG1000-211 CABLE CHAIN ATTACHMENT
3HXG1000-216 EDGE LIST
3HXG1000-224 SCREW
3HXG1000-226 ALLEN SCREW
3HXG1000-25 Clamping unit
3HXG1000-253 GUARD SCREEN
3HXG1000-262 CONTACT GREASE
3HXG1000-284 PROTECTOR HOSE
3HXG1000-285 GRIP UNIT
3HXG1000-292 LUBRICATING NIPPLE
3HXG1000-4 TERMINAL BLOCK MARKING
3HXG1000-413 MAGNALUBE-G GREASE
3HXG1000-48 T-CROSS
3HXG1000-49 ADAPTER
3HXG1000-5 VALVE BISTABLE
3HXG1000-506 BUSHING NC910
3HXG1000-51 CONNECTING ANGLE
3HXG1000-516 Brush holder
3HXG1000-52 CABLE CHAIN LINK
3HXG1000-53 CASING
3HXG1000-55 CONTACT SOCKET
3HXG1000-556 REDUCE NIPPLE
3HXG1000-558 THREADED COUPLING.
3HXG1000-56 SQUEEZE BUSHING
3HXG1000-561 ANGLE COUPLING
3HXG1000-562 Oil brush
3HXG1000-563 STABILISATOR
3HXG1000-585 SOLENOID VALVE-BüRKERT
3HXG1000-586 TIMER-BüRKERT
3HXG1000-587 GREASE CONTAINER
3HXG1000-588 E-PUMP TRABON
3HXG1000-589 DIVIDER VALVE
3HXG1000-591 COUPLING
3HXG1000-600 T-SCREW NUT
3HXG1000-615 COUPLING, STRAIGHT
3HXG1000-68 CONNECTION FEMALE 4P
3HXG1000-69 Cabel
3HXG1000-70 POWER CABLE
3HXG1000-86 Roller block
3HXG1000-94 CABLE ATTACHMENT 16-22 O
3HXG1000-95 CABLE ATTACHMENT 12-16 O
3HXG1101-1 O-RING
3HXG1101-2 O-RING
3HXG1105-1 PARALLEL PIN
3HXG1106-4 PLASTIC HOSE PUN-6X1
3HXG1111-3 HOSE
3HXG1111-5 Hose
3HXG1111-6 HOSE
3HXG1111-8 HOSE
3HXG1111-9 HOSE
3HXG1117-3 ROTO GLYDE
3HAB2869-1 Ext. located op panel 15m
3HAB2870-1 Ext. located op panel 22m
3HAB2909-1 Female insert 72p
3HAB2909-2 Male insert 72p
3HAB2916-1 Resistor
3HAB2924-1 Wheel bracket
3HAB2927-1 Rubber moulding
3HAB2945-1 Transf. EU 400-500V
3HAB2946-1 Transf. USA 475-600V
3HAB2947-1 Transf. JAP 200-400V
3HAB2950-1 Transf. EU, 400-500V
3HAB2951-1 Transf. USA 475-600V
3HAB2952-1 Transber JAP 200V,2
3HAB2955-1 Housing with locking
3HAB2957-1 Jumper
3HAB2986-1 Contact socket
3HAB2987-2 Gasket
3HAB2989-2 Component unit
3HAB2995-2 House bulkhead mounting
3HAB2995-4 House bulkhead mounting
3HAB2997-1 Wrist band
3HAB3031-1 Parallel bar
3HAB3126-1 Parallel arm
3HAB3144-1 Gearbox 2,3
3HAB3201-1 Housing axis 4
3HAB3203-1 Cable unit axis 1-3
3HAB3204-1 Cable unit axis 4-6
3HAB3205-1 SIGNAL CABLE
3HAB3206-1 ADAPTER CABLE
3HAB3208-1 Cable unit axis 4-6 CC
3HAB3210-1 Gear axis 4, step 2
3HAB3211-1 Pinion axis 4, step 2
3HAB3212-1 Gear axis 4, step 1
3HAB3213-1 Pinion axis 4, step 1
3HAB3220-1 Cover axis 1-3
3HAB3221-1 Cover
3HAB3223-1 Cover axis 5-6
3HAB3225-1 Bracket
3HAB3226-1 Bracket
3HAB3228-1 Bracket
3HAB3230-1 Bracket
3HAB3231-1 Bracket
3HAB3233-1 Bearing house, axis 4
3HAB3254-1 Cushion axis 3
3HAB3256-1 Shaft
3HAB3257-1 Damper
3HAB3258-1 Stop pin
3HAB3259-1 Stop, axis 2 Complete
3HAB3260-1 Washer
3HAB3261-1 Sealing
3HAB3262-1 Spacer
3HAB3263-1 Tension spring
3HAB3264-1 Spacer
3HAB3265-1 Shaft
3HAB3266-1 Cover
3HAB3269-1 Stop, axis 3 complete
3HAB3272-1 Gear box , axis 1-3
3HAB3281-1 Lower arm
3HAB3282-1 Parallel arm
3HAB3283-1 Parallel bar
3HAB3286-1 STOP AXIS 1 comp
3HAB3287-1 Heat shield
3HAB3288-1 SPOUT HEAT SHIELD
3HAB3289-1 NUT
3HAB3290-1 Bracket
3HAB3291-1 Spring
3HAB3293-1 Sealing
3HAB3296-1 Sync.market axis 1-2
3HAB3297-1 Sealing
3HAB3298-1 Cableguide
3HAB3299-1 Holder for cableguide
3HAB3310-1 Cable pos.indicator ax.1
3HAB3321-1 Connections box ax. 1-3
3HAB3322-1 Cable box M4
3HAB3326-1 Gasket M1-3
3HAB3327-1 Gasket M4-6
3HAB3328-1 Cable guide
3HAB3333-20 Coupling
3HAB3347-1 Gasket bottom plate
3HAB3348-1 Gasket
3HAB3361-1 Bottom plate
3HAB3362-1 Cable unit axis 1-3
3HAB3363-1 cable unit axis 4-6
3HAB3364-1 Cable unit axis 4-6
3HAB3367-1 Bracket
3HAB3370-1 Bracket
3HAB3380-1 Gear unit axis 4
3HAB3384-1 Cable unit axis 4-6 CC
3HAB3385-1 Cable unit axis 4-6 CC
3HAB3388-1 Wrist
3HAB3396-1 Bracket
3HAB3402-14 Hex socket head cap screw
3HAB3402-15 Hex socket head cap screw
3HAB3402-24 Hex socket head cap screw
3HAB3402-25 Hex socket head cap screw
3HAB3402-26 Hex socket head cap screw
3HAB3402-28 Hex socket head cap screw
3HAB3402-30 Hex socket head cap screw
3HAB3402-36 Hex socket head cap screw
3HAB3402-37 Hex socket head cap screw
3HAB3402-38 Hex socket head cap screw
3HAB3402-39 Hex socket head cap screw
3HAB3402-44 Hex socket head cap screw
3HAB3402-51 Hex socket head cap screw
3HAB3402-52 Hex socket head cap screw
3HAB3404-14 Hex socket head cap screw
3HAB3409-200 Hex socket head cap screw
3HAB3409-205 Hex socket head cap screw m20x90
3HAB3409-23 Hex socket head cap screw
3HAB3409-24 Hex socket head cap screw
3HAB3409-25 Hex socket head cap screw
3HAB3409-26 Hex socket head cap screw
3HAB3409-27 Hex socket head cap screw
3HAB3409-29 Hex socket head cap screw
3HAB3409-37 Hex socket head cap screw
3HAB3409-38 Hex socket head cap screw
3HAB3409-39 Hex socket head cap screw
3HAB3409-40 Hex socket head cap screw
3HAB3409-42 Hex socket head cap screw
3HAB3409-50 Hex socket head cap screw
3HAB3409-51 Hex socket head cap screw
3HAB3409-52 Hex.sock.head cap screws
3HAB3409-53 Hex socket head cap screw
3HAB3409-57 Hex socket head cap screw
3HAB3409-59 Hex socket head cap screw
3HAB3409-60 Hex socket head cap screw
3HAB3409-61 Hex socket head cap screw
3HAB3409-62 Hex socket head cap screw
3HAB3409-67 Hex socket head cap screw
3HAB3409-71 Hex socket head cap screw
3HAB3409-73 Hex socket head cap screw
3HAB3409-74 Hex socket head cap screw
3HAB3409-75 Hex socket head cap screw
3HAB3409-84 Hex socket head cap screw
3HAB3409-85 Hex socket head cap screw
3HAB3409-86 Hex socket head cap screw
3HAB3409-88 Hex socket head cap screw
3HAB3409-89 Hex socket head cap screw
3HAB3409-90 Hex socket head cap screw
3HAB3409-92 Hex socket head cap screw
3HAB3409-93 Hex socket head cap screw
3HAB3438-1 Spring
3HAB3443-1 Foot
3HAB3538-12 Sealing strip
3HAB3539-1 END LID (VK-cover)
3HAB3582-1 Resistor/Diode
3HAB3610-1 Gear set
3HAB3613-1 Gear
3HAB3614-1 Pinion
3HAB3615-1 Pinion ax. 4-6 / Z1
3HAB3616-1 Pinion ax. 5/Z3
3HAB3617-1 Gear
3HAB3618-1 Gear
3HAB3629-1 Shaft end
3HAB3630-1 Bottom plate
3HAB3631-1 Gasket
3HAB3632-1 Washer
3HAB3633-1 Ring
3HAB3637-1 Driving shaft
3HAB3639-1 Cushion ax.2
3HAB3640-1 Spring washer
3HAB3641-1 Driving shaft ax 6
